Servicios Personalizados
Revista
Articulo
Indicadores
- Citado por SciELO
- Accesos
Links relacionados
- Similares en SciELO
Compartir
Revista mexicana de física
versión impresa ISSN 0035-001X
Rev. mex. fis. vol.52 supl.2 México feb. 2006
Highly porous tungstenoxidebased films obtained by spraygel for gas sensing applications
J.L. Solisª ,b, J. Rodríguezª,b, and W. Estradaª,b
ª Instituto Peruano de Energía Nuclear, Av. Canadá 1470, San Borja, Lima 41, Perú.
b Facultad de Ciencias, Universidad Nacional de Ingeniería, Casilla 31139, Lima, Perú. email: jsolis@uni.edu.pe
Recibido el 27 de octubre de 2004
Aceptado el 26 de mayo de 2005
Abstract
Highly porous mixed WO3SnO2 films have been prepared from an aqueous solution of SnCl4.5H2O and polytungsten gel with a molar ratio of Sn/W from 0 to 1. These solutions were sprayed on to alumina substrates at 220°C. The obtained films were annealed at 600°C in air for 3 h. The annealed films were composed of a mixture of WO3 and SnO2 phases. The gas sensitivity to butanol and ethanol vapors is enhanced when the Sn/W molar ratio increases in the film by up to 0.1, with further increments to this proportion the sensitivity decreases.
Keywords: Tungsten oxide; tin oxide; gas sensor; pyrolysis.
Resumen
Películas delgadas muy porosas de mezclas de WO3SnO2 se prepararon a partir de una solucion de SnCl4.5H2O y gel polytúngstico con una relación molar de Sn/W de 0 a 1. Estas soluciones fueron pulverizadas sobre substratos de alumina a 220°C. Las películas obtenidas fueron sinterizadas a 600° C en aire por 3 h. Las películas están compuestas de una mezcla de las fases de WO3SnO2 y SnO2. La sensitividad a vapores de etanol y butanol es mejorada cuando la razón molar de Sn/W se incrementa en la película hasta 0.1, para mayores incrementos a esta proporción la sensibilidad decrece.
Descriptores: Oxido de tungsteno; oxido de estaño; sensor de gas; pirolisis.
PACS: 81.15.Rs; 81.05.Rm
DESCARGAR ARTÍCULO EN FORMATO PDF
Acknowledgements
This work has been financially supported by the International Program for Physical Science of Uppsala University (IPPS), the Instituto de Investigación of Universidad Nacional de Ingenieria, and CONCYTEC (Peruvian Research Council).
References
1. K. Zakrzewska, Thin Solid Films 391 (2001) 229. [ Links ]
2. M.J. Madou and S.R. Morrison, Chemical Sensing with Solid State Devices, (Academic Press, San Diego, 1989). [ Links ]
3. Y.S. Shen and T.S. Zhang, Sens. Actuators B 12 (1993) 5. [ Links ]
4. Z. Szklarski, K. Zakrzewska, and M. Rekas, Thin Solid Films 174 (1989) 269. [ Links ]
5. J.L. Solís and V. Lantto, Sens. Actuators B 48 (1998) 322. [ Links ]
6. J.L. Solís et al., Sens. Actuators B 68 (2000) 286. [ Links ]
7. M. Macek, B. Orel, and T. Meden, J. SolGel Sci. Technol. 8 (1997) 771. [ Links ]
8. M.A. Damian, Y. Rodríguez, J.L. Solís, and W. Estrada, Thin Solid Films 444 (2003) 104. [ Links ]
9. A. Medina, J.L. Solís, J. Rodriguez, and W. Estrada, Sol. Energy Mater. Sol. Cells 80 (2003) 473. [ Links ]
10. C.V. Gopal Reddy, W. Cao, O.K. Tan, and W. Zhu, Sens. Actuators B 81 (2002) 170. [ Links ]
11. T. Jinkawa, G. Sakai, J. Tamaki, N. Miura, and N. Yamazoe, J. Mol. Catal. A: Chem. 155 (2000) 193. [ Links ]
12. F. Hellegouar'h, F. ArefiKhonsari, R. Planade, and J. Amouroux, Sens. Actuators B 73 (2001) 27. [ Links ]